Interesting Facts on Samurai Sword Manufacture
A samurai's sword is his most sacred and prized possession. Not only did the samurai rely on his sword to defend him, but spiritually the sword held greater significance as the samurai actually believed his soul inhabited the sword. Therefore it comes as no surprise that the same discipline and respect in which the samurai wielded his sword, went into the actual making of the sword itself. Swords weren't simply 'cast' in a mould and then sharpened. A Japanese samurai sword was made by an intricate process of heating the steel, hammering it flat, then folding it, then hammering it flat again, and folding. This process of repeated hammering and folding would be done up to as much as 30 times, or until the maker was satisfied it had been done properly. There are quite a few reasons for this labour-intense procedure. Firstly, any air pockets which might develop during the heating of the steel would be eliminated. Having an air pocket in a seemingly solid blade would be a weak point, and any weak point would be seen as neglect and any dedicated artisan would produce the highest quality blades as if his own life depended upon the very blade he was forging. Secondly, in the repeated folding and hammering, what might be described as 'layers' were produced. Take a book and roll it up it parallel with the spine, these internal layers would look something like this, almost like the rings of a cross section of a tree trunk. This added much strength to the blade. Also the natural strengthening carbon elements within the steel, as well as the steels impurities would be spread throughout the whole of the sword, therefore strengthening it in its entirety. When the blade came to be cooled it wasn't simply quenched in water, another process had to be done first. When steel is been cooled, if it cools from a high temperature right down to cold in a short amount of time, the metal becomes very hard and brittle. Conversely, if steel is cooled slowly from a lower temperature right down to cold, the steel takes on more supple, even softer properties. Because a samurai sword was used primarily as a slicing weapon the blades were subjected to a lot of shock upon impact on the enemy, therefore the blade couldn't be made of the more brittle steel throughout else it would shatter like glass. But the sword had to retain its sharp edge, so it couldn't be made of softly forged steel throughout else it would simply blunt. So a balance was struck using a very clever procedure. What the Japanese samurai sword makers discovered was by painting on a clay formula onto the blade before quenching, thin amounts onto the cutting edge and thicker amounts onto the back, the steel could be made to take on two completely separate properties, thereby giving the blade the hard cutting edge it required, and the more supple back. Because of the different speeds in which the two halves of the steel cooled this also formed the beginning of the curve from which the sword makers would work to create the famous curved blade. Article by Nick Johnson, visit his website for more on samurai swords
http://www.japanese-samurai-swords.net
Related News
|
 |
|
|
RELATED ARTICLES
New Book: Positive Aikido
A new book with a practical look at Aikido and its history. The Co-authors are direct students of the legendary master Kenshiro Abbe Sensei from 1957. the following is an indepth look at how the book came into being.
Makiwara Training
Shigeru Kimura Sensei 9th Dan Tani-Ha Shitoryu Shukokai had a punch that was like getting hit with a cannonball.
Samurai Swords and The Swordsmiths
Back in the early times of sword manufacture, the production of super strong high-grade carbon steel wasn't even a vague dream. But we know, as history has taught us, that sword makers of ancient times still managed to produce superb quality, strong weapons.
Martial Arts Strength Training
According to various sources on the internet, a 1996 article in Iron Man Magazine revealed Bruce Lee's workout. In addition to his cardio and karate workouts, Lee lifted weights three times a week and performed the following routine:
COMBATIVES A Rose by Any Other Name?....Part 2
The advent of World War One (the war to END all wars) brought warfare into a new and foreboding era of man to man killing and slaughter. Air power, mechanized warfare, chemical warfare and the general widespread use of machine guns changed the face of battle almost completely. However the solitary fact remained that in the end it was STILL man against man in a desperate, brutal and deadly struggle for survival. The static and stagnant lines created by entrenched warfare demanded new and innovative tactics and strategies. Among these was the advent of "raiding" parties. Small groups of lightly armed men who ventured out into "no man's land" for the purpose of recon, probing, intelligence, prisoner grabs, and psychological "demoralization" missions. The nature of fighting under these conditions became popularized as "trench warfare". This was close-in knife to belly hand to hand combat. All manner of expedient, purpose designed and improvised close-combat weaponry was employed. While technological advances were being made in all other forms of warfare, this particularly nasty and vicious man to man fighting reverted to the most barbaric, primitive and bloody "methods" imaginable. Just as it has been since Cain slew Abel and how it WILL be until the last two humans clench fists or seize stones in raging anger during the final melee of the Apocalypse.
Content, Are We?
I asked a simple question at the last seminar:
Elements of Unarmed Combat
Custom build your own personal "system":
Real Life Self-Defense Starts From...
"Nicky Bats" was an "old school" kinda guy. He was "street" thru and thru. He was a hard bark tough as nails S.O.B. He was a survivor. His definition of "success" in life was dying peacefully at a ripe old age of natural causes, not dying on some frozen blood-soaked battlefield in Korea after being over run by a human swarm of Chi-Coms. Not winding up in a landfill dead of lead poisoning and not dying in some filthy gutter with your innards spilling out from a gaping knife wound.
Interesting Facts on Samurai Sword Manufacture
A samurai's sword is his most sacred and prized possession. Not only did the samurai rely on his sword to defend him, but spiritually the sword held greater significance as the samurai actually believed his soul inhabited the sword. Therefore it comes as no surprise that the same discipline and respect in which the samurai wielded his sword, went into the actual making of the sword itself.
A Samurais Power Is In His Little Finger, Not His Samurai Sword
In the 12th Century the Shogunate was formed. The head of this regime was the Shogun, the supreme ruler. Under him where his regional 'daimyo' or 'dukes'. Under each 'daimyo' served the Japanese samurai. When a samurai stepped out of line, became too unruly or displeased his 'daimyo', the samurai would often have to go through a procedure known as yubizume. This procedure is a very barbaric punishment in which the first joint of the little finger on the sword hand would be amputated.
Tae Kwon Do As A Means To Stay In Shape
Becoming a martial artist is a fanatastic method of fitness. While there are many martial art forms to choose from, taekwondo is clearly the most beneficial, and the most practical. And while many realize the benefits of such exercise, the simple fact is most have no idea how to begin.
Im Soooo Confused...
I was going to write about the BASICS of "practical unarmed combat". Things like a solid and productive core of strength training, development of real speed and power. Body conditioning and toughening, Stamina. A "never say die" iron will. You know "esoteric" stuff like that.
Are You Frustrated Yet?
I was talking to a parent recently and they told me that their son was not going to compete in wrestling because they were afraid they would get frustrated when he lost. The parent felt the child was far too sensitive to handle the frustration of failure and may get 'burnt out'. My response was, "What will they do when they get frustrated in life?" What happens when that kid has got to suck it up and go forward when it REALLY counts?
Being a new parent, my daughter is 2 and I have another on the way, I only want the best for my child. What parent doesn't? It's obvious this parent I mentioned loves their child, but that's not the issue. The issue is what's best for everyone involved. What this child is being taught is to quit when things get tough. In an effort to protect the child, the parent winds up doing a disservice to the child. The result is undermining the ultimate goal- the training of the child.
Fronting
"Fronting": The dodge to get in close to you. The frontal assault, as opposed to the ambush.
How to Become A Modern-Day Ninja Master
The ninja were a military order in Japan. Most people have seen them in movies and fictional books.
Grown Man Quits After 3 Mat Pulls!
A matt pull is the simple act of lying on flat on your stomach, reaching in front of you and pulling your self across the mat. This is one exercise that helps develop your muscles for grappling. We do these as a part of our warm up.
Who Created Tai Chi Chuan (Tai Chi Boxing)?
I have read a number of books, articles, and novels, and have watched movies and television series that touched on the origins of Tai Chi Chuan (Tai Chi Boxing), and the question, "Who Created Tai Chi Chuan?" made me concern very much!
Bogu Training
About four years ago Carl recommended we start using the Bogu during our kumite (sparring practice). This method was developed in Okinawa and then found its way into mainland Japan and eventually to the U.S. where only a few clubs still do this. And even in those clubs, only a few members do it. I know there is other equipment out there that looks similar and I have used most of what's available. But it does not provide you with nearly the same overall effect that the bogu does. Rules in bogu training ? Any punch, any kick, save foot stomps, a strike to the spine and to the back of the neck. Throws and leg kicking is certainly allowed. Use, dare I say, your commonsense.
The Fallacy and the Myth
It's always amusing when "know it alls" dismiss certain methods out of hand as being useless or "unworkable". One "victim" of this line of thinking is the "cross arm" or "X" block (for lack of a better term).
Why Every Cop Should Study Judo Part 1
Up until 30 years ago, JUDO was the martial art. Then with the introduction of the more mysterious martial arts with more of a "killing" edge to them this coupled with the focus of the USJF/USJI (the leading Judo organizations in the US and the world) focus on Olympic competition and the simple fact that training in judo is painful and to this day, very difficult to get a black belt rank in it, especially if you are in a competitive area. I could probably write another 5 pages on this, but I will stay on point.
|
